矿井提升机.doc
《矿井提升机.doc》由会员分享,可在线阅读,更多相关《矿井提升机.doc(66页珍藏版)》请在启牛文库网上搜索。
1、 摘 要 矿井提升机 是矿山重要设备,肩 负着矿石、材 料、人员运输 责任。传统的矿山机械 和电气控制 系统采用绕组转子串联电阻 调速,控制电 路复杂、效率低、能耗 大等缺点。所以提升 控制系统的研究 具有重要 的现实意义。 本文针对当 前矿井提升机 电控系统的现 状,在可编程序 控制器(PLC)和变频器的基 础上,研究并设 计了一套可靠性 高、控制性能良 好的矿井提升机控制 系统。分 析了PLC和变频 器的性能特点 并进行选型,论 文根据矿用提升机的 运行特性要求,对变 频器和PLC进行 选型,最终选定 西门子公司的S7-200 PLC 和ABB公司的ACS800 变频器。对系统的软、 硬件
2、进行设计,最后进行系 统集成和调 试,选用MCGS组 态软件 来完成矿井提 升机控制系统的上位监控。关键词 矿井提 升机 变频器 PLC MCGSABSTRACTMine hoist is the most important equipment in mines, is shouldering the ore, materials, personnel transportation liability. Traditional mine mechanical and electrical control system adopts winding rotor series resistanc
3、e speed control, poor control circuit is complex, high performance, high failure rate, power consumption, low efficiency of faults, so the mine hoist control system Research has practical significance.This article in view of the current status of mine mechanical and electrical control system, the pr
4、ogrammable controller (PLC) and frequency converter, on the basis of research and design a set of high reliability, good control performance of mine hoist control system. Analyzes the performance characteristics of PLC and frequency converter and selection, the paper according to the requirements of
5、 the mine hoist running characteristics, the selection of frequency converter and PLC, finally selected Siemens S7-200 PLC and ABB ACS800 inverter. The system hardware and software design, finally carries on the system integration and debugging, use the MCGS configuration software to complete the up
6、per monitoring of mine hoist control system.Key words Mine hoist Inverter PLC MCGS目 录摘 要IAbstractII第1章 绪 论11.1 引言11.2 国内外研究现状11.2.1国外提 升机的研究现状21.2.2国内提升机的研究现状31.3系统技术要求31.4提升机电气传动系统速度图41.5方案比较6第2章 矿井提升机及其电气控制系统72.1矿井提升机种类72.2矿井提升机主要组成部分及其作用72.3变频调速基本原理9第3章 提升机控制系统硬件设计103.1 变频器选择103.2 确定合理的经济速度103.3
7、提升机滚筒直径的确定123.4 提升机的最大静张力计算133.5 电动机功率的估算133.6 估算电动机转速143.7 加速度和减速度的确定153.8 设备选型173.8.1 断路器选择193.8.2 隔离开关选择203.8.3 熔断器选择203.8.4 输入电抗器设计213.8.5 接触器选择243.8.6 制动电阻选择253.8.7 PLC选型273.8.8 触摸屏选型283.8.9 深度指示器系统选择283.8.10 角编码器选择29第4章 提升机控制系统软件设计314.1 PLC软件设计314.1.1 主程序及注释324.1.2 故障子程序及注释404.1.3 逆变子程序及注释464.
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 矿井 提升